Online Service

Auto Division-Nancy    
Industrial Division-Bob    
Marine Division-Kip    
G-Drive Division-Jenny    
Genset Division-Wicky    

CUMMINS 400KW Biogas Generator Set

CUMMINS 400KW Biogas Generator Set from China
CUMMINS 400KW Biogas Generator Set

CUMMINS SCBG400K Biogas Generator Set 

Rated Output(KW) 400
Standby Output(KW) 440
Voltage(V) 400
Current(A) 720
Size(mm) 3620*1700*2310
Approximate weight(KG) 6880
Emission levels (Nox) Euro II emission(mg/m³)
Naturally aspirated engine intake air temperature None
Air temperature before entering the air to air intercooler   82-87(Deg C)
Air temperature after entering the air to air intercooler   45-55(Deg C)
Rated Power @ 0.8 power factor (w / pump s and w / o fan) 400KW (continuous operation)
Total energy input (100% load) 1150(KW)
Electrical efficiency 34.80%
Thermal efficiency 84.00%
Control panel(Deepsea or others) Synchronizing Control, Multilingual Mode Digital Control, Diagnostic Function, Direct Text Indicate of Faults, MOBUS Communication Protocol, Compatible Communication, Exchange Telecommunications,  Wired Control Data Output, Automatic or manual start
   

Engine of CUMMINS SCBG400K Biogas Generator Set 

Engine Model KT38
Type V type 12 cylinders
Bore * Stroke (mm) 159*159
Displacement(L) 37.8
Compression ratio 9.5:1
Rated speed(rpm) 1500/1800
Inlet type Naturally aspirated
Cooling type Cooling water tank
Fuel System Low and high pressure
ESC Type Special for U.S. GAC Biogas
Ignition sequence 1-5-3-6-2-4
The allowed maximum speed(Biogas supply closed at this time) 2160 rpm
The allowed maximum rotating speed (The ignition system shut down at this time) 2160 rpm
Oil Capacity 135 L
Cooling water capacity 290 L
Maximum engine back pressure 10.2 kpa
Gas consumption(m3∕kw·h) <0.5
Rough oil consumption(g/kWh) <1.6
Radiator and oil cooler heat 135 KW
Exhaust pipe heat radiation 207 KW
Engine thermal radiation 26 KW
Alternator thermal radiation 18 KW
Cooling water temperature 95 Deg C
Oil temperature <120 Deg C
Exhaust pipe heat energy (above 120 º C section) 360 KW
Exhaust temperature (before vortex ) 650±25 Deg C
Exhaust Flow 3350 m³/h
Fan exhaust flow 14 m³/s
Noise level from 1 m  <100 db(A)
   

Alternator of CUMMINS SCBG400K Biogas Generator Set 

Alternator Model Engga EG315L-400N
Excitation Method Brushless Permanent Magnet
Winding pitch 2/3 pitch
Number of poles 4
Bearing number 1
Stator Windings 12 ends
Insulation Class H class
Protection class IP 21 or IP 23
Load type Continuous operation
AVR Model WT-2
Alignment Fly wheel
Temperature Range Less than 125 degrees Celsius
Overload  Capacity- the percentage of rated power 110%
Waveform distortion rate, no-load <5%
Voltage Regulation Mode AVR
Voltage Regulation Range ±5%
Steady State Voltage Regulation ±1%
No-load line voltage sine wave distortion ±2%
Telephone interference factor (TIF) < 50

Welcome to contact us for more information of CUMMMINS Biogas Generator Set.
Click here to find more China CUMMINS Generator Set.